Carolina Chopped Pork Barbecue Sandwiches With Spicy Vinegar Sauce Recipe Epicuriouscom Food

CAROLINA VINEGAR BBQ SAUCE

Steps:

• Add all ingredients to a small saucepan. Bring to a boil then reduce to simmer cooking for 2 minutes until sugar and salt dissolves.
• Remove from heat and let cool. Store in a covered jar or bottle in the refrigerator until ready to use. It can be stored for up to 3 weeks.

NORTH CAROLINA-STYLE BBQ PULLED-PORK SANDWICHES

Steps:

• Make small holes all over the pork shoulder with a thin sharp knife and stuff in garlic cloves. Rub the meat all over with the Memphis Shake; cover and refrigerate overnight.
• Prepare an outdoor grill with an indirect medium-hot fire with a mix of briquettes and hardwood charcoal in half of the grill. Set grate over coals. Place pork, skin side up, in an aluminum pan with about 1 1/2 cups water on the cooler side of the grate. Toss 1 cup of the soaked and drained wood chips onto the coals and cover the grill, making sure the lid's vents are directly over pork.
• When the coals cool to medium-low heat, preheat a chimney-full of hot briquettes and hardwood charcoal. Whenever smoke stops coming out of the vents, about every hour, add more hot coals and 1 cup of soaked and drained wood chips to the fire. The goal is to maintain a medium-heat, smoky fire (but don't worry if it is hotter when the coals are added and cooler while preheating the coals). Rotate the pork when you add coals so it cooks evenly. Cook the meat until an instant-read thermometer inserted into the thickest part of the pork registers 180 degrees F, about 6 hours.
• Set aside 1 quart of the North Carolina-Style Vinegar BBQ Sauce. Once the pork reaches 180 degrees F, begin mopping the entire surface of the meat every 20 minutes with some of the remaining sauce and the pan drippings. Continue to cook the pork, covering the grill between mopping, until an instant-read thermometer registers 200 degrees F, about 1 to 2 hours more.
• Transfer the pork to a cutting board and let rest for at least 15 minutes. Remove the outer skin and discard. Cut large chunks from the bone and shred, using 2 forks or your fingers, (when cool enough to touch) or chop. Toss with about 1 cup of the reserved barbecue sauce for every 3 cups of meat. Tuck the pork into the soft rolls and serve with pickles.
• Whisk paprika, brown sugar, oregano, garlic, ancho powder, salt, and celery salt in a small bowl. Store in an airtight container in a cool, dry place for up to 2 months.
• Heat the vinegar and sugar in a medium saucepan over medium heat until the sugar dissolves. Off the heat, stir in the ketchup, honey, salt, red pepper, and black pepper.

CAROLINA-STYLE PORK BBQ SANDWICHES

Steps:

• Make the pork:
• Spray the inside of a slow cooker with cooking spray.
• Put the onions in the slow cooker. Make slits in the pork roast and insert the garlic cloves. Rub salt, pepper, brown sugar, and red pepper flakes into the meat. Place the pork in the slow cooker fat side up and pour in the vinegar and apple cider. Cover and cook on low for at least 10 hours and up to 12 hours, until the meat is falling-apart tender.
• Transfer the meat to a large bowl and shred it with two forks. Set aside.
• Make the sauce:
• Pour 2 cups of the pan juices into a measuring cup; discard any leftover juices still in the pot. Let cool and skim off any visible fat. Pour this liquid into a saucepan. Add the water, ketchup, cider vinegar, brown sugar, Worcestershire sauce, chili powder, paprika, dry mustard, and red pepper flakes. Bring to a boil and simmer, uncovered, for 10 minutes. Season with salt and pepper. Return the shredded pork to the slow cooker and add 1 cup of the sauce mixture (more if you like it wet). Give it a stir and set the slow cooker to warm until ready to serve.
• Assemble the sandwiches:
• Serve the pork straight from the slow cooker with a slotted spoon, along with buns, slaw, and hot sauce. Serve the additional sauce on the side.

NORTH CAROLINA PULLED-PORK BARBECUE

Steps:

• Bring vinegar to a boil with sugar, red-pepper flakes, 2 tsp salt, and 1 Tbsp pepper in a small nonreactive saucepan, stirring until sugar has dissolved, then cool. Set aside 2 cups vinegar sauce to serve with sandwiches.
• While sauce cools, score pork skin in a crosshatch pattern with a sharp knife (forming 1-inch diamonds), cutting through skin and fat but not into meat. Pat meat dry and rub all over with 1 Tbsp each of salt and pepper. Let stand at room temperature 1 hour before grilling.
• Prepare grill for indirect-heat cooking over low heat, leaving space in middle for disposable roasting pan.
• When coals have cooled to about 300°F (45 minutes to 1 hour; when most coals will have burned out), put disposable roasting pan on bottom rack of grill between the 2 remaining mounds of coals, then fill pan halfway with water. Add a couple of handfuls of unlit charcoal to each charcoal mound, then put grill rack on so hinges are over coals.
• Oil grill rack, then put pork, skin side up, on rack above roasting pan. Grill pork, with lid ajar (for air, so coals remain lit), basting meat with sauce and turning over every 30 minutes (to maintain a temperature of 250 to 275°F, add a couple of handfuls of coals to each side about every 30 minutes), until fork-tender (a meat fork should insert easily) and an instant-read thermometer inserted 2 inches into center of meat (avoid bone) registers 190°F, 7 to 8 hours total.
• Transfer pork to a cutting board. If skin is not crisp, cut it off with at least 1/4 inch fat attached (cut any large pieces into bite-size ones) and roast, fat side down, in a 4-sided sheet pan in a 350°F oven until crisp, 15 to 20 minutes.
• When meat is cool enough to handle, shred it using 2 forks. Transfer to a bowl.
• Serve pork, cracklings, and coleslaw together on buns. Serve reserved vinegar sauce on the side.

SOUTH CAROLINA CHOPPED BARBECUE

Steps:

• In a Dutch oven, combine the pork, garlic, vinegar and peppercorns and add enough water to cover. Bring liquid to a boil over moderately high heat, skimming the froth as it rises to the surface. Simmer, partially covered, for about three hours, or until very tender.
• Meanwhile, prepare the sauce by combining the vinegar, pepper and salt in a covered container, shaking vigorously to blend.
• Preheat oven to 350 degrees.
• Remove the pork from the Dutch oven, discarding the liquid. Place pork on the rack of a roasting pan, and baste thoroughly with the spicy sauce. Baste every 15 minutes or so, turning the meat after 1 1/2 hours. It should roast for a total of about three hours with constant basting, so it does not dry out. The fat should be crisp.
• Remove pork from the oven, chop very finely with a large knife, and sauce again. The mixture should be moist, but not soupy. Serve warm, with cole slaw and white bread.

CAROLINA BBQ SANDWICH

Steps:

• Preheat the oven to 325 degrees F.
• Sprinkle the Boston butt with the Cajun spice, 1 tablespoon salt and 1 teaspoon pepper and put in a deep roasting pan. Add the diced vegetables and bay leaves, and then cover with chicken stock. Wrap with plastic wrap and tightly cover with foil. Roast until tender, 2 to 2 1/2 hours.
• Remove the pork from the stock and let cool. Remove the fat from the stock and measure out 1 cup of the stock and cooked vegetable mixture. Let cool slightly, and then put in a blender. Add the mustard, hot sauce, white balsamic, brown sugar, cumin, paprika and some salt and pepper and puree until smooth. Taste the sauce and add more salt and pepper if needed.
• Shred the pork with two forks. In a saucepot over medium-low heat, add the pulled pork and toss with the sauce to coat, stirring throughout. Warm, stirring, until hot, about 15 minutes.
• To assemble the sandwiches: Stack the bottom brioche buns with some sauced pork and top with the coleslaw followed by the bun tops.

CAROLINA CHOPPED PORK BARBECUE SANDWICHES WITH SPICY VINEGAR SAUCE

Steps:

• Combine first 8 ingredients in heavy large saucepan. Simmer over medium heat 5 minutes. Remove from heat, cover, and let stand 2 hours.
• Place handful of torn newspaper in bottom of charcoal chimney. Top with 30 charcoal briquettes. Remove top rack from grill. Place chimney on lower grill rack. Light newspaper; let charcoal burn until ash is gray, about 30 minutes.
• Open bottom grill vent. Turn hot charcoal onto 1/2 of bottom rack. Using metal spatula, spread charcoal to cover approximately 1/3 of rack. Fill 2 small foil loaf pans halfway with water and place next to charcoal on bottom rack. Sprinkle 1 cup chips over coals.
• Place top rack on grill. Arrange pork shoulder halves on top rack above loaf pans. Cover grill with lid, positioning top vent directly over pork. Place stem of meat thermometer in top vent with gauge on outside and tip near roast (thermometer should not touch meat or grill rack); leave in place during cooking. Use top and bottom vents to maintain temperature between 250°F and 325°F, opening vent wider to increase heat and closing to decrease heat. Leave other vents closed. Check temperature every 20 minutes.
• Cook pork 3 hours. About once an hour, light more charcoal in chimney set on bricks or cement to replenish charcoal in grill. Add 12 hot ash-tinged briquettes and 1 cup drained wood chips when cooking temperature drops below 250°F. Using sharp knife, make several crosswise slashes in meat (do not cut through). Brush with some of sauce. Cover and continue cooking pork until meat thermometer inserted into center of pork registers 165°F, about 2 1/2 hours longer, adding additional hot briquettes and chips as necessary to maintain temperature and basting occasionally with sauce.
• Transfer pork to cutting board; remove any tough rind. Chop meat into bite-size pieces. Transfer meat to large bowl and add enough sauce to moisten. Arrange bun bottoms on work surface. Top buns with pork; cover with tops. Serve, passing additional sauce.

NORTH CAROLINA EASY CHOPPED BARBECUE

Steps:

• Preheat oven to 325 degrees F. Wrap pork in aluminum foil and place in a broiler pan. Cook for 7 hours, about 1 hour per pound. Remove from oven and let stand for 1 hour.
• Wearing heavy rubber gloves, pull skin from the meat and discard. Remove most of the fat and all of the bone. Cut meat into 8-ounce chunks and place in large pan.
• Place meat on a charcoal fire and cook, covered, for another 30 to 45 minutes, until well smoked, turning meat over every 10 to 15 minutes. Pour barbecue sauce over meat during the last 10 to 15 minutes of cooking.
• Remove meat from the grill and chop into bite size pieces. Serve with additional barbecue sauce if desired.
• Mix all ingredients in a 6-quart stainless steel pot. Bring to a boil, then simmer, about 15 minutes. Turn off heat and let stand, about 30 minutes. Sauce can be refrigerated for up to 2 weeks.

BBQ PULLED PORK WITH CAROLINA SAUCE

Steps:

• For the Carolina BBQ sauce: Combine the cider vinegar, ketchup, sugar, molasses, mustard, soy sauce, tomato paste, Worcestershire sauce, red pepper flakes, salt and a pinch ground black pepper in a stainless steel saucepan over medium heat. Bring the mixture to a boil, reduce the heat and simmer for 10 minutes. Remove from the heat and let cool before using. If not using immediately, pour it into a bowl or jar. Cover and refrigerate until needed.
• For the BBQ pulled pork: Combine 1-quart water with the soy sauce, salt, sugar, honey and molasses in a large saucepan over medium heat. Bring the mixture to a boil, then remove from the heat and let cool. Stir in 1 gallon plus 3 quarts water. Pierce the meat with a boning knife in several places, then add the meat to the brine. Cover and refrigerate overnight.
• Remove the meat from the brine, coat lightly with salt and pepper, and arrange in a smoker. Load 2 boxes filled with applewood chips into the smoker. Set the smoker at 250 degrees F and smoke for 8 hours. Remove the meat from the smoker to a cutting board and shred when cool enough to handle. Arrange on a serving platter and serve with the BBQ sauce.

CAROLINA STYLE PULLED PORK SANDWICH

Steps:

• The Meat --.
• Place the quartered onions in a crock pot.
• Combine brown sugar, paprika, salt and pepper: rub over the roast.
• Place the roast over the onions in the crock pot.
• Combine the vinegar, Worcestershire Sauce, red pepper flakes, sugar, mustard, garlic salt and cayenne; stir to mix well.
• Drizzle about 1/2 of the vinegar mixture over the roast and cover. Refrigerate the remaining vinegar mixture.
• Cook on low for 8 hours. Drizzle the other half of the vinegar mixture over the roast during the last 1/2 hour of cooking.
• While the meat is cooking, prepare the barbecue sauce. Mix all ingredients except soy sauce, butter and smoke. Simmer, uncovered, on low heat for 30 minutes. Stir in the remaining ingredients and simmer, uncovered, for 10 more minutes. Set aside to cool.
• Remove the meat from the crock pot and allow to rest for at least 15 minutes. (Very important step -- longer is better).
• Remove the onions and chop to a fine consistency.
• Pull apart the meat with a couple of forks. Meat should have a shredded look to it.
• Mix chopped onions and shredded pork along with a little bit of juice from the crock pot to taste. Add sufficient barbecue sauce to the mixture to achieve desired taste. Meat should have distinctive barbecue flavor.
• To serve, spread barbecue sauce on bottom of a hearty bun.
• Put layer of pulled pork on bun. Spread barbecue sauce over meat.
• Add layer of your favorite cole slaw on top of meat. Layer some more barbecue sauce over cole slaw.
• Spread top of bun with more sauce.
• Grab a fist full of napkins, and enjoy.

CAROLINA-STYLE PORK BARBECUE

Steps:

• Cut roast into quarters. Mix brown sugar, salt, paprika and pepper; rub over meat. Place meat and onions in a 5-qt. slow cooker., In a small bowl, whisk vinegar, Worcestershire sauce, sugar and seasonings; pour over roast. Cook, covered, on low 6-8 hours or until meat is tender., Remove roast; cool slightly. Reserve 1-1/2 cups cooking juices; discard remaining juices. Skim fat from reserved juices. Shred pork with two forks. Return pork and reserved juices to slow cooker; heat through. Serve on buns with coleslaw.

PULLED PORK SANDWICHES WITH WEST CAROLINA BARBECUE SAUCE

Steps:

• Make the sauce: in a saucepan over med-high heat, melt the butter and cook the onion, stirring occasionally, until translucent-4 to 5 minutes.
• Add in the remaining sauce ingredients; bring to a boil.
• Decrease heat and simmer for 10 minutes; set aside and let cool to room temperature.
• Let roast stand at room temperature for 20-30 minutes before grilling; season with salt and pepper.
• Grill roast, fat side up, over Indirect Medium heat until the internal temperature is between 185° and 190°, 3-4 hours.
• The meat should be so tender it pulls apart easily.
• Remove from grill, place on a platter, and loosely cover with foil; let rest for 20 minutes.
• Thinly slice, chop, or pull the pork meat into shreds with your fingers or two forks, discarding any large bits of fat.
• Moisten the meat with some of the sauce and mix well in a bowl.
• Grill the buns over Direct Medium heat until lightly toasted, about 30 seconds.
• Serve the pork warm on the buns with the remaining sauce on the side.

CAROLINA-STYLE PULLED PORK BARBECUE & SAUCE

Steps:

• Sauce:.
• Combine all ingredients in a non-aluminum saucepan and bring to a boil. Lower heat and simmer 15 minutes. Cover and remove from heat, let stand for 30 minutes.
• Using funnel, return sauce to vinegar bottle and store in refrigerator.
• Shake well before using.
• PORK:.
• Wrap pork shoulder in wide, heavy duty aluminum foil. Meat may be basted with about 1/4 cup of the Carolina sauce before wrapping.
• Place in shallow roasting pan. Bake at 325℉ for 1 hour per pound.
• If cooking a whole pork shoulder, 10 - 13 pounds, wrap as directed, and.
• bake at 300℉ for 1 hour per pound.
• OR if using slow cooker, wrap as directed, and cook on low for 10 hours.
• When done, remove meat from oven and open foil a little to vent. Rest until cool enough to handle. Remove meat to cutting board. There will be quite a bit of liquid inside the foil; pour into quart jar and refrigerate. Remove fat from top after it has hardened.
• Using 2 large forks or your gloved hands, pull fibers of meat apart. Meat may be sliced or chopped if you prefer. Remove and discard bones and large pieces of fat and membrane. Place pulled meat in a large bowl, and sprinkle with about 1/2 cup of Carolina Style Sauce. Stir to blend, taste, and add more sauce as desired. Commercial bottled barbecue sauce may be used if you prefer.
• Serve hot, in sandwich buns, with Carolina cole slaw.

NORTH CAROLINA BARBECUE SANDWICH SAUCE

Steps:

• Melt the butter in a large, heavy saucepan over medium high heat.
• Add the onion and saute 3 minutes.
• Add the remaining ingredients and bring to a boil, stirring frequently.
• Reduce heat and simmer, reducing saucec to 2& 2/3 cups.
• Season with salt and pepper.
• Serve with sliced or chopped pork roast or roast beef.