Construction Grade Gingerbread Food

CONSTRUCTION GRADE GINGERBREAD

Steps:

• Preheat oven to 325 degrees F
• Pour sugar into mixer
• Heat honey in the microwave for 20-30 seconds, then pour onto sugar
• Mix until combined
• Add water and eggs
• Mix until combined, scraping the sides as you go
• Add ginger, cinnamon, and cloves
• Mix until combined, scraping the sides as you go
• Add flour one cup at a time
• Mix until smooth
• Switch your mixer to a dough hook and continue to mix
• Add more flour if needed, until the dough starts to separate itself from the sides of the bowl
• Remove dough from bowl and put into a gallon ziplock bag
• Refrigerate for an hour (optional but recommended)
• Flour the surface of a baking mat and start rolling the dough out
• Use a flour duster if it's sticky
• Roll until flat and cut out your gingerbread pieces
• Bake the pieces at 325 degrees F for 15-20 minutes, rolling the dough once after 10 minutes
• When the pieces are firm, remove them from the oven, lay them on a flat surface, then put the pan on top of them so they cool nice and flat
• Build and decorate!

GINGERBREAD FOR HOUSES

Steps:

• Into a large bowl, sift together flour, spices, baking soda, salt, and pepper; set aside. In a large saucepan, melt shortening over medium-high heat, about 4 minutes. Whisk in sugar and molasses until well combined. Remove from heat, and stir in the flour mixture until just combined but still crumbly. If dough is still sticky, add a bit more flour.
• Turn out dough onto a large piece of plastic wrap, and wrap to enclose completely; let cool slightly, 10 to 15 minutes.
• Preheat oven to 325 degrees, and line two baking sheets with parchment paper. Divide dough into two equal parts, and place on prepared baking sheets. While dough is still slightly warm, roll out gently but firmly to a 3/8-inch thickness. Cut out desired shapes, and remove excess dough from around cutters or templates.
• Bake 30 minutes, rotating sheets halfway through. Transfer to a wire rack to cool completely before decorating.

CONSTRUCTION GINGERBREAD RECIPE

Steps:

• For the Dough: Trim a sheet of parchment paper to fit the interior of a half sheet pan. Adjust oven rack to lower-middle position and preheat to 350°F (175°C). Combine brown sugar, cinnamon, ginger, cloves, salt, corn syrup, butter, and vanilla in the bowl of a stand mixer fitted with a paddle attachment. Mix on low until smooth, then sprinkle in flour and continue mixing to form a stiff dough. Turn onto a lightly floured surface and knead until smooth. Proceed immediately, or wrap in plastic and set aside at room temperature until needed, up to 24 hours. (Larger batches should be divided into 14-ounce portions.)
• Sprinkle prepared parchment with flour, place dough on top, and flatten into a rectangle. Sprinkle with more flour and roll to fit just within edges of parchment, leaving dough about 3/16 inch thick. Using both hands, transfer parchment to a half sheet pan. Cut according to your gingerbread house template, using an X-Acto or paring knife. Leave a narrow border of dough around cutouts to minimize spreading, but trim away larger areas of excess dough to gather and re-roll, or turn into paste (see directions below).
• Bake gingerbread until dry to the touch and golden brown, about 25 minutes. Immediately cut along pre-scored lines with a sharp knife or pizza wheel. Cool completely in pan, then transfer cutouts to a safe place. Scraps can be nibbled, or ground in a food processor to use in recipes that call for cookie crumbs.
• For the Paste: Return scraps to mixing bowl and resume mixing on low speed. Begin adding water, 1 teaspoon at a time, until scraps form a stiff but pipeable paste. Thoroughly scrape bowl and beater with a flexible spatula to eliminate lumps, then continue mixing until perfectly smooth. Transfer to a piping bag fitted with a small round tip. Pipe designs, such as fences and railing, onto a parchment-lined half sheet pan and bake until pale gold, about 12 minutes. Cool completely before handling. If you like, assemble with Sturdy Royal Icing .