Homemade Bacon Dry Cured And Air Dried Food

HOME-CURED STREAKY BACON

Steps:

• Tip the salt and sugar into a freezer bag and shake well. Slip the pork into the bag, seal and scrunch around with your hands until the pork is completely covered in the cure.
• Lay the pork flat in the fridge and leave for five days, turning occasionally. The dry cure will turn into a wet brine as the liquid is released from the meat.
• After the five days, lift the pork from the bag, rinse it off and pat it dry. It's now ready to slice into rashers and cook. Will keep in an airtight container for one week.

HOMEMADE BACON (DRY CURED AND AIR DRIED)

Steps:

• Combine the sugar and salt. Generously rub the flesh side of the pork belly with the mixture.
• Rub the sugar and salt into the flesh some more.
• Did I mention you need to rub the 'ol pork belly down with the sugar and salt? The sides too. Make sure to get any pockets or under bits of fat - anywhere where water could accumulate. All of it, man.
• Stack the pork belly slab (or slabs) into the large plastic bin. Stick in the refrigerator and forget about it until the next day. Dump the accumulated liquid out of the plastic bin and rerub the flesh with the sugar and salt. Stack it all back in the tub and stick it in the fridge again.
• The next day, dump out any accumulated liquid and rub the sugar and salt mixture on any part of the pork belly where the salt and sugar has been completely dissolved. A thin layer will do. Repeat this process every day until liquid stops accumulating in the bin. Ours took about 10 days.
• Rinse the pork belly under water, using your fingertips to scrub off any remaining sugar and salt. Pat dry.
• Voila! Cured bacon. We ran meat hooks through ours and hung it up in the kitchen.

HOMEMADE BACON

Steps:

• **REFER TO BLOG POST FOR A COMPREHENSIVE TUTORIAL AND STEP-BY-STEP PROCESS****You can vary the flavors according to your preferences (see Recipe Notes) but do not adjust the salt or Prague powder amounts**
• For the Wet Cure Method:Add all the cure ingredients together in a large bowl and stir. Place the pork belly in gallon ziplock bag or container that just fits the size of the pork belly and pour the brine over it. If using a ziplock bag, place the bag in a container in case there is any leakage. Place it in the refrigerator for 7 days, flipping the bag over (or the pork belly itself if curing it in a container) every 2 days to ensure both sides of the pork belly are equally cured.**A one-gallon bag will hold a 3-pound pork belly. If you're following the recipe to use a 5 pound pork belly and plan on using the wet cure method with ziplock bags you can cut the pork belly in half and divide the brine equally between the two bags.
• After 7 days the pork belly will have firmed up. Remove the pork belly from the brine and thoroughly rinse it off. Some people say you should let the slab of bacon air dry for up to 24 hours before you smoke it. But many experts agree there is no need to do this. These experts argue that in leaving it wet the smoke actually sticks to the bacon better than if it's dry. At this point if you like you can rub it down with some cracked peppercorns and, if you want it sweeter, some brown sugar, honey or maple syrup. Proceed to smoking (see below).
• For the Dry Cure Method:Place all the dry cure ingredients in bowl and stir to thoroughly combine them. It is essential that the pink curing salt is evenly distributed across the whole pork belly. We recommend using a spice/coffee grinder, a small blender or a mortar and pestle. Thoroughly and evenly rub down all sides of the pork belly with the dry rub. Place it in a ziplock bag or container (like a casserole dish), with the fatty layer side down, and cover it with plastic wrap. Refrigerate it for 5 days. Flip the bacon over, redistribute the liquid that will have formed (if it's in a ziplock bag simply turn the bag over and give it a massage), and refrigerate for another 5 days. After 10 days the pork belly will have become quite firm and stiff. Remove it from the the container or bag, rinse thoroughly, and pat dry with paper towels. At this point if you like you can rub it down with some cracked peppercorns and, if you want it sweeter, some brown sugar, honey or maple syrup. Proceed to smoking.
• To Smoke the Bacon:Preheat your smoker to 175-180 degrees F (do not exceed 200 F). (We use and love the Masterbuilt Digital Smoker). Smoke the bacon fat side up (as the fat renders it will run down over the meat) for 3+ hours or until the internal temperature of the bacon reaches 150 degrees F. (We use and recommend this instant read thermometer.) Add a handful of wood chips a couple of times during the smoking process. (Good options include hickory, apple or cherry.)If you're using a grill, set up it up for 2-zone cooking and smoke the bacon over indirect heat at 175-180 degrees F (don't exceed 200 F) for about 3 hours or until the internal temperature of the bacon reaches 150 degrees F.Once the bacon reaches an internal temperature of 150 degrees F, transfer the bacon to a plate and immediately place it in the fridge to cool down.
• To slice the bacon, slice it across the grain. You can use a large sharp knife or, for perfectly uniform/professional slices use a meat slicer.
• To store the bacon: If you plan on using the bacon within 2 weeks, wrap it in several layers of plastic wrap followed by an outer layer of foil and keep it refrigerated. If you're not going to use it within 2 weeks you can freeze it for up to 3 months. To freeze the bacon: You can either use a vacuum sealer like Food Saver or you can lay the slices out on wax paper in the same fashion as store-bought bacon and place another sheet of wax paper over it. Fold the sides around the bacon. Place the wrapped bacon in a ziplock bag. If you prefer the pieces not to stick together you can cut strips of was paper and place them between each slice of bacon. When you're ready to use it, simply remove the bacon from the freezer and let it thaw.

HOME-CURED BACON

Steps:

• Place the pork belly in a large Ziploc bag. Add the salt (and pink salt if using) and the cure additions. Rub the cure into the pork belly, turning the bag over and over and pressing the cure into the flesh. Close the bag, squeezing out all the air and refrigerate for seven days. Each day, flip the bag over. Some liquid will begin to gather in the bag.
• After seven days, wash the cure off the meat, rinsing thoroughly. Pat the bacon dry with paper towels and set it on a rack over a baking sheet. Allow the bacon to air-dry in the refrigerator for 6 to 24 hours.
• Preheat the oven to 225 degrees. Roast the pork belly in the oven to an internal temperature of 150 degrees for about 90 minutes. Chill the bacon well, then slice thick or thin, to preference. Any bacon that doesn't easily slice may be cut into chunks, for starting a pot of beans or soup. Wrapped in parchment paper, then wrapped in plastic wrap or foil and placed in a Ziploc bag, the bacon will keep for three weeks in the refrigerator and three months in the freezer.