Canning Roasted Peppers Food

MARINATED ROASTED RED PEPPERS CANNING RECIPE

Steps:

• Wash your jars, lids, screw bands, and canning tools in hot soapy water. Rinse well to remove all suds. Set aside to air dry on a clean kitchen towel.
• Place the jar rack into water bath canner, place jars in the canner, and add water to cover. Bring the canner to a simmer (180˚F) for 10 minutes, and keep the jars hot until you are ready to fill them.
• Rinse peppers well under clean, running water. Cut each pepper in half, and remove the stems, seeds, and ribs.
• Blister the skins of your peppers by grilling or broiling until the skins crack and separate from the flesh.
• Remove the peppers from the heat and place in a covered glass bowl to steam.
• Once the peppers are cool enough to handle, remove the skins, and tear or cut into pieces or strips. Divide the peeled roasted peppers evenly into piles to match the number of jars.
• Heat about 1 tablespoon of the olive oil in a large saucepan over medium heat. Add the onions and garlic and sauté briefly until fragrant, about 2 minutes.
• Add the remaining olive oil, vinegar, lemon juice, dried oregano, and sugar if using. Bring to a boil, and then reduce the heat to low. Keep warm until you are ready to use.
• Spread a kitchen towel on the counter. Use your jar lifter to remove a jar from canner, drain, and place on the towel. Keep the remaining jars in the canner so they stay hot.
• Fill the jar with roasted peppers, leaving a 1/2-inch headspace. Give your marinating brine a good stir to be sure the oil is evenly distributed. Use your canning funnel and ladle to fill the jar about halfway with the brine.
• Run your bubble popper through the jar to mix the peppers with the brine, and top off with more brine leaving a 1/2-inch headspace. Run the bubble popper through the jars again to remove air bubbles.
• Wipe the rim with a damp towel to remove residue. Center a lid on the jar, place the band over the lid, and screw it on until fingertip tight. Place the jar back into the canner, and repeat with the rest of the jars.
• Once jars are all in canner, adjust the water level so it is 2-inches over the tops of the jars.
• Cover the canner and bring the water to a rolling boil over medium-high heat. Once the water is boiling, process both half-pints and pints for 15 minutes at altitudes of less than 1,000 ft. Adjust processing time for your altitude if necessary (See Notes below).
• When processing time is complete, turn off heat, remove the cover by tilting lid away from you so that steam does not burn your face, and allow the canner to cool down and settle for 5 minutes.
• Spread a kitchen towel on the counter. Use a jar lifter to remove the jars one at a time from the canner. Keep the jars upright, and place them on the towel. Do not tighten ring bands or test the seals yet. Let the jars sit undisturbed for 12 to 24-hours to cool.
• After the jars have cooled for at least 12 hours, check to be sure lids have sealed by pushing on the center of the lid. The lid should not pop up. If the lid flexes up and down, it did not seal. Refrigerate the jar and use within 2 weeks.
• Remove the screw on bands and wash the jars. Label, date, and store the jars of marinated red bell peppers in a cool, dark location between 50 to 70 degrees F for 12 to 18 months.
• For best flavor, let the jars sit for at least 4 weeks before opening to allow the flavors to develop. Refrigerate after opening and use up within 2 weeks. Yields about 8 half-pint or 4 pints.

CANNING PEPPERS (HOT OR SWEET)

Steps:

• Wash peppers before beginning.
• Roast peppers on all sides to blister the skin, using either a grill, stovetop burner or oven broiler for 8-10 minutes. A grill outdoors is my preferred method.
• After roasting, place peppers on a tray under a damp towel for about 15 minutes. This will help the skins slip.
• Remove the towel and slip the skins of the peppers. Be sure to use gloves for hot peppers. Working under running water in the sink helps the skins slip easier.
• Use a sharp paring knife to cut around the stem of each pepper and remove the stem, seed and core of each pepper. For hot peppers, simply cut off the top of each pepper and then remove the seeds. (Again, gloves are important here for hot peppers!)
• Pack the peppers into prepared canning jars, either as whole peppers, slices or dices. For whole peppers, smash the pepper flat before sliding it into the jar (3-4 whole peppers per pint). Be sure to leave 1 inch headspace.
• Prepare a pressure canner according to the manufacturers instructions. This usually means adding 2-3 inches of water to the bottom of the canner and bringing it up to a simmer with the bottom trivet in place.
• Bring a kettle of water to a boil on the stove and fill jars with boiling water, maintaining 1 inch headspace. De-bubble jars, adjust headspace, wipe rims and seal with 2 part canning lids to finger tight. Load into a preheated pressure canner.
• Place the lid on the pressure canner, but do not start bringing it up to pressure. Allow steam to vent for 10 minutes before adding the canning weight and bringing the canner up to pressure (see notes for pressure).
• Once at pressure, process jars for 35 minutes. Canning in pints or half pints is acceptable, but don't use quarts or larger jars. Be sure to maintain pressure for the entire process time, and if the canner drops below pressure, re-start the timer.
• Once the jars have processed at pressure for 35 minutes, turn off the heat and allow the canner to cool completely before removing the jars. (Don't ever attempt to rapid cool a pressure canner.)
• When cool, remove the jars and check seals. Store any unsealed jars in the refrigerator for immediate use. Properly processed and sealed jars should maintain quality on the pantry shelf for 12-18 months.

CANNING ROASTED RED PEPPERS

Steps:

• Preheat oven to 400 F.
• Line a baking sheet with parchment paper. Lay the peppers, skin up, on the baking sheet in one layer, spray the peppers with the oil and roast in the oven for 10 to 20 minutes until the skin starts to wrinkle and separate from the peppers.
• Remove the baking sheet from the oven and use a spatula to add the hot peppers to a Ziplock or produce plastic bag. Close the bag and let the peppers rest for 10 minutes or so.
• While the peppers are resting in the bag, fill your pressure canner with 2'' of water and set it on the stovetop. Turn the heat to high and bring the water to a simmer (180 degrees F). Wash your jars, lids, and rings and set them aside.
• Open the bag and let the peppers cool for a minute then peel your peppers. The skin should separate easily at this point.
• Add 1/2 teaspoon of salt to each pint jar or 1/4 teaspoon to each half-pint jar. If you like the taste of vinegar, you can add up to 1 1/2 teaspoons of vinegar to each jar.
• Pack the jars with peppers, making sure to leave 1'' headspace then add boiling water to each jar still making sure to leave 1'' headspace.
• Use the bubble remover to remove air bubbles. Then, use a clean paper towel to wipe the rim of each jar before centering the lid and closing the jar with the ring.
• Set your filled jars in the pressure canner on the rack. Close the canner and turn the heat to high. Let the canner vent for 10 minutes before placing the weight on the vent.If you are using a dial gauge canner, process the jars under 11 psi for 35 minutes. If you are using a weighted gauge canner, process under 10 psi for the same amount of time. Make sure to adjust processing time according to the table below if you live in altitudes above 1000 feet.
• Once the time is up, turn the heat off and let your canner cool slowly. When the canner has cooled completely, open the lid and let the jars rest in the hot water for 10 more minutes. Use the jar lifter to remove the jars and set them on a kitchen towel on the kitchen counter to cool for 12 hours undisturbed.
• Wipe jars, remove rings (cause they rust and stick), label and store in the pantry for up to 18 months.

CANNED ROASTED PEPPERS OR PIMENTO

Steps:

• Preheat oven to 450 F.
• Place whole peppers on an ungreased baking sheet and place in moderately hot oven for 8 to 10 min.
• or until skin blisters and browns.
• Remove from oven and place clean tea towel over peppers until completely cooled.
• Halve peppers and remove skins, stem and seeds.I use the tea towel to "scrub" off the skins.
• Flatten peppers and pack in hot clean pint jars.
• Add scant 1/2 tsp.
• canning salt to each jar.
• No additional liquid is neeed.
• Adjust lids and process according to your pressure cooker directions for 10 minutes at 10 pounds of pressure.