Canning Chili Base Food

HOW TO CAN CHILI

Steps:

• While cooking chili, prepare your pressure canner, with 3" of simmering water. Prep jars and lids according to safe USDA canning guidelines.
• Brown ground beef, diced onions and diced green pepper in a large pan until fully cooked. Drain grease and discard. Transfer meat mixture to a very large stockpot.
• Add canned diced tomatoes, kidney beans, chili beans, pinto beans, and black beans to meat mixture. Stir. Add water,spices and Worcestershire sauce. Stir all ingredients well to combine. Cook chili on medium-high until it begins boiling. Give it a taste, and adjust salt, if necessary.
• Fill prepared (clean & hot) canning jars with hot chili, leaving a 1" headspace in each jar. Remove air bubbles with utensil, and adjust headspace, if necessary. Wipe jar rims clean with a wet dishcloth, to ensure a good seal. Center flat lids on top and screw down rings until fingertip tight. Process quart jars at 10# pressure for 90 minutes. If using pint jars, process at 10# pressure for 75 minutes.
• Once processing time is completed, let pressure drop to zero naturally, then follow instructions for safely removing vent and lid. PLEASE follow your pressure canners manufacturer instructions!
• Remove HOT jars of chili, place onto a dish towel on counter (don't place jars directly on counter as temperature variations could lead to cracking the jars). Let jars sit and cool undisturbed overnight. Once completely cooled, check to ensure each jar is properly sealed, wipe down jars, label each one, and store in pantry!

HOMEMADE CHILI IN A CAN

Steps:

• Place ground beef into a soup pot over medium heat, and cook and stir until the meat is browned, breaking it up into crumbles as it cooks, about 10 minutes. Stir in onion and garlic, and cook until the onion is translucent, about 5 more minutes. Drain excess grease if necessary, and sprinkle the meat with taco seasoning mix; cook the meat with the seasoning for 1 or 2 more minutes.
• Pour in the chili-flavored tomatoes, chili beans, tomato sauce, and diced green chilies, and stir to combine; simmer for 30 minutes to blend flavors.

HOME CANNED CHILI

Steps:

• Wash dried beans. Place in large pot, cover with about 5 to 10 cm (2 to 4 inches) of water, let stand overnight or 12 to 18 hours.
• Drain, discard soaking water.
• Put in large pot, cover with fresh water (optional: add a few bay leaves), bring to a boil, then lower to a simmer covered for 30 minutes.
• Meanwhile, combine ground beef, onion and pepper, and fry until beef is browned. Drain in a mesh strainer, colander or on paper towel to get excess grease off.
• Drain beans (tip: you can freeze the bean stock as a base for delicious soups).
• Return beans to their large pot, and add the beef mixture, the tomatoes, and all the flavourings. Stir, bring to a boil, then lower to simmer for 5 minutes to ensure all is heated through evenly.
• Pack into heated jars: either 1/4 litre or 1/2 litre (1/2 US pint or 1 US pint), leaving 3 cm (1 inch) headspace.
• Debubble; adjust headspace.
• Wipe jar rims.
• Put lids on.
• Processing pressure: 10 lbs (69 kPa) weighted gauge, 11 lbs (76 kpa) dial gauge (adjust pressure for your altitude when over 300 metres / 1000 feet.)
• Processing time: Process either size of jar for 75 minutes .

CHILE CON CARNE (CANNING)

Steps:

• Wash beans thoroughly and place them in a 2 qt saucepan.
• Add cold water to a level of 2 to 3 inches above the beans and soak 12 to 18 hours.
• Drain and discard water.
• Combine beans with 5-1/2 c of fresh water and 2 tsp salt and bring to a boil.
• Reduce heat and simmer 30 minutes.
• Drain and discard water.
• Brown ground beef, chopped onions and optional peppers in a skillet.
• Drain off fat and add 3 tsp salt, pepper, chili powder, tomatoes and drained cooked beans.
• Simmer 5 minutes.
• CAUTION: Do Not Thicken.
• Fill jars, leaving 1" headspace.
• Adjust lids and process in pressure canner.
• Dial Gauge Pressure Canner:.
• 75 minutes.
• 11 lb at 0-2,000 ft (altitude); 12 lb at 2,001-4,000 ft; 13 lb at 4,001-6,000; 14 lb at 6,001-8,000 ft.
• Weight Gauge Pressure Canner:.
• 75 minutes.
• 10 lb at 0-1,000 ft; 15 lb at above 1,000 ft.